Defensor PH28A Provozní pokyny

OPERATING INSTRUCTIONSAdiabatic Humidifiers2560479 EN 1108Defensor PH28/PH28A

10Walter Meier (Climate International) Ltd. 8808 PfäfkonType: PH28A Serial: XXXXXXX 07.11Voltage: 220...240VAC / 50...60 Hz Power: max. 128 WWater p

11Twosilverionisationelectrodespreventtheformationofslimeandmicroorganismsinthebasetubandonthehumidicationdrum.Theionizerelectr

12Theairpurier/airhumidierDefensorPH28/PH28Aisdeliveredinacardboardbox(W:900mmxH: 820 mm D: 490 mm, transport weight: 49 kg),ready

134.1 Unpacking the unit and checking the scope of deliveryUnpacking the unitOpenthepackingandremovetheunitandtheaccessories.Checkthedeli

144.3 Choose locationPleaseobservethefollowingnotesforthecorrectpositioningoftheDefensorPH28/PH28A:– Placetheunitonasolidhorizonta

15– Install the air outlet grills in a way that the moist air can leave the unit unhampered and make suretheairowisnotdirectedtowardsobstacl

164.5 Putting the unit into operationProceedasfollowstoputtheDefensorPH28/PH28Aintooperation:• PH28:llthewatertank(seechapter5.1)PH

175 Operation5.1 Fillingthewatertank(PH28only)142536SwitchofftheDefensorPH28anddisconnecttheunitfromthemains(pull the mains plu

185.2 Switching the unit on and offSwitching the unit on• Pressthe<On/Off> key.The unit loads the settings that were active when the device

19TimerOnTimeMo 12:00Monday 118:00 45%rH BA3Monday 2--:-- 45%rH BA0Sunday 1--:-- 45%rH BA0Sunday 222:00 45%rH BA0^Act 38%rH BA3 Set 45%rHSet value

205.4 Unit settings (normal operating mode)5.4.1 Setting the desired humidity valuemodifyconrmcancelNote:Thereferencehumidityvaluecanbemodi

21Note:Thefanstepcanbemodiedonlyifprogrammodeisdeactivated(seechapter5.5).Available settings: 1, 2, 3, 4 or Auto1, Auto2, Auto3, Auto

22BuzzerOffBuzzerNew ValueBuzzerOld ValueBuzzerOff5.4.4 Switching the buzzer on and off(see chapter 5.4.3)(see chapter 5.4.5)modifyconrmcancelOnor

23TimerOnTimerAdjust5.4.5 Calling timer level(see chapter 5.4.4)(see chapter 5.4.6)Calling timer levelLeaving timer levelFordetailedinformationreg

245.5 Program operationTheoperationoftheDefensorPH28/PH28Acanbecontrolledviacustomisableoperatingprograms.Theseprogramsallowtooperat

255.5.2 Activating/Deactivating the program modeAvailablesettings: On(programmodeactivated)orOff(programmodedeactivated)Factorysetting: O

26Monday 1--.-- 45%rH H0Monday 1New ValueMonday 1Old ValueMonday 1--.-- 45%rH BA0Monday 2--.-- 45%rH BA0Sunday 2--.-- 45%rH BA05.5.4 Setting the star

275.6 Locking/unlocking the keyboardThekeyboardoftheDefensorPH28/PH28Acanbelockedtopreventunauthorizedaccesstothestored settings. • T

286 Maintenance6.1 Maintenance intervalsTheDefensorPH28/PH28Acanonlyprovidefullhumidicationandpuricationperformanceiftheunitis regul

296.2 Maintenance work6.2.1 Disassembling the unitSwitchofftheDefensorPH28anddisconnecttheunitfromthemains(pull the mains plug out

31 Introduction 41.1 To the very beginning 41.2 Notes on the operating instructions 42 For your safety 63 Product Overview 83.1 Unit versio

30Unit component What to clean and how to cleanBase tub, Retaining net,Rotaryhumidicationdrum• Wash partswithalukewarmsoapsolution and rin

31Unit component What to clean and how to cleanCoarsedustlters(Quattrolters) • Cleanthecoarsedustlters(Quattrolters)ontheinnerside

326.3 Notes on cleaning agentOnly use cleaning agents stated in the table above.Theuseofdisinfectantsisonlypermittediftheydonotleaveany

336.4 Reassembly of the unitCAUTION!BeforereassemblingtheDefensorPH28checkallcomponentsforpossibledamage.Donotreusedamagedpartsbutre

346.5 ResettingthelterchangingmessageAfterthereplacementoftheltersandtheevaporatormatthelterchangingmessagecanberesetasfoll

35Theoperatingvoltageisspeciedonthetypeplatelocatedinsidetheunit. DANGER!Neverusefusesthatdonotmatchtheabovespecicationsandd

367 Fault eliminationDisplay DescriptionRadio sensor K1Install.? ESC/ECause: Ifanewbatteryisinsertedintotheradiohumiditysensor(op-tion)a

377.3 Error messagesDisplay red LED Buzzer Error relay ResettingError 1Cover openError message is displayed until the water tank carriage (PH28) or

387.4 What, if...?ThefollowingtablelistssymptomsofmalfunctionthatmayoccurindailyoperationoftheDefensorPH28/PH28A, together with possi

397.5 Notes on fault elimination DANGER!FortheeliminationoffaultssettheDefensorPH28/PH28Aoutofoperation, separate the unit from the mains

4LimitationThesubjectofthisoperatinginstructionsaretheairpuriers/airhumidiersDefensorPH28and PH28A.Thevariousaccessoriesareonlyd

408 Taking out of service/DisposalIftheDefensorPH28/PH28Amustbereplacedoriftheunitisnotneededanymore,proceedasfollows:1. Switchof

419 UnitspecicationsDimensions(BxHxT) 800x750x440mmWeight (empty) 43 kgOperating weight 73 kgWater tank capacity 30 lMains voltage 220…24

4210 Appendix10.1 Wiring diagramB1/B2 Ionisation electrodesB3 Level switchF1 Fuse control board (1.25 A, slow acting)M1 4-stepfanM2 Drum motor

4310.2 SparepartslistPH2816537101112132027313798243633323435381917181415542422232156525125185350162829302655

44Pos. Art.-No. Spare parts designation1 2560541 Outlet grill2561710 Outlet grill special color (RAL or NCS code according type plate)2 1109392 Fan cp

4510.3 SparepartslistPH28A1660 62 6163537101112132027318243633323435381917181415242223216525162829302664379

Pos. Art.-No. Spare parts designation1 2560541 Outlet grill2561710 Outlet grill special color(RAL or NCS code according type plate)2 1109392 Fan cpl.3

© Walter Meier (Climate International) Ltd. 2011, Printed in SwitzerlandTechnical modifications reserved

Reg.No. 40002-2Manufacturer:Walter Meier (Climate International) Ltd.Talstr. 35-37, P.O. Box, CH-8808 Pfäffikon (Switzerland)Phone +41 55 416 61 11, Fax

5Symbols used in this manualCAUTION!Thecatchword“CAUTION”designatesnotesinthisoperatinginstructionsthat,ifneglected,maycause damage and/o

62 For your safetyGeneralEverypersonworkingwiththeDefensorPH28/PH28AmusthavereadandunderstoodtheOperatinginstructionsbeforecarryingo

7Danger that may arise from the unit DANGER! Danger of electric hazard!TheDefensorPH28/PH28Aismainspowered.Onemaygetintouchwithliveparts

83 Product Overview3.1 Unit versionsTheDefensorPH28/PH28Aairpurier/airhumidierisavailableintwobasicversions:– PH28: version with inte

9 1 Air outlet grill 2 Radialfan 3 Rotaryhumidicationdrum 4 Evaporator mat 5 Base tub 6 Coarsedustlter(Option:Quattrolter) 7